Where are the accessories of concrete mixer and all-in-one mixer? The accessories of all-in-one mixer are indispensable to the production of mixer. Because some mixers are used for too long, the maintenance is not timely, and coupled with the long-term wind and sun, some parts will be worn or rusted. Therefore, the accessories need to be prepared by customers in advance. What are the common mixer accessories, Where can I buy the concrete mixer? Let's introduce it to you.

中科聚峰搅拌机选用的是耐磨钢材，此类钢材有更好的刚度和强度，制成的搅拌机使用寿命更长；而一些小厂家生产的搅拌机，采用的是普通钢材，成本价格要远低于耐磨钢材。尤其是搅拌机易磨损配件的材质，如果质量低劣的话会直接影响到搅拌机的使用寿命。

Zhongke Jufeng mixer adopts high-quality wear-resistant steel, which has better stiffness and strength, and the service life of the mixer is longer; The mixers produced by some small manufacturers use ordinary steel, and the cost price is much lower than that of high-quality wear-resistant steel. In particular, the material of easily worn parts of the mixer will directly affect the service life of the mixer if the quality is poor.

中科聚峰混凝土搅拌机常用配件混凝土搅拌机常用的配件有：衬板，传感器，大轴，电动滚筒，电磁阀，搅拌电机，料斗滑轮，减速机，搅拌臂、钢丝绳，轴端密封，叶片，输送带，添加剂蝶阀，托辊，行程开关等，这些都比较常见，在施工时应及时更换。

Common accessories of Zhongke Jufeng concrete mixer common accessories of concrete mixer include: lining plate, sensor, large shaft, electric drum, solenoid valve, mixing motor, hopper pulley, reducer, mixing arm, steel wire rope, shaft end seal, blade, conveyor belt, additive butterfly valve, idler, travel switch, etc. These are common and should be replaced in time during construction.

磨损严重的混凝土搅拌机配件有叶片、衬板，钢丝绳，料斗滑轮

The seriously worn concrete mixer accessories include blades, lining plates, steel wire ropes, hopper pulleys

一、叶片、衬板，搅拌机工作是依靠拌筒内搅拌轴上安装的搅拌叶片，对加入拌筒内的物料进行强力搅动，从而实现对混凝土物料的搅拌。搅拌机转速较快、叶片易磨损。平均搅拌5-10万方混凝土后需更换一次。

1、 The work of the blade, lining plate and mixer depends on the mixing blade installed on the mixing shaft in the mixing drum to strongly stir the materials added into the mixing drum, so as to realize the mixing of concrete materials. The rotating speed and blades of the mixer are easy to wear. After mixing 50000-100000 m3 of concrete on average, it needs to be replaced once.

二、钢丝绳工作中钢丝绳磨到龙门架易造成磨损，正常情况下6-9个月需更换一次。

2、 During the operation of the steel wire rope, the steel wire rope is easily worn to the gantry, and it needs to be replaced every 6-9 months under normal circumstances.

三、料斗滑轮滑轮长时间负载滚动，易造成磨损。滑轮只要能用肉眼明显观察出来磨损就必须进行更换，滑轮只要磨损一部分就会导致料斗上下爬行出现震动，对轨道造成损害，甚导致轨道变形。

3、 The hopper pulley rolls under load for a long time, which is easy to cause wear. As long as the wear of the pulley can be clearly observed with the naked eye, it must be replaced. As long as a part of the pulley is worn, it will cause the hopper to crawl up and down, vibration, damage to the track, and even lead to track deformation.