欢迎您访问莱州聚峰机械有限公司网站!
点击拨打服务热线:150-5352-4111
大家都在搜: 4.0方自上料搅拌机 0.5方自上料搅拌机 0.5方自动上料搅拌机设备

0.5方自动上料搅拌机设备

来源:http://www.zkhntjbj.com/日期:2020-04-26 浏览量: TAG:混凝土搅拌机、自动上料搅拌机、搅拌一体机

概述:自动上料搅拌机其中一个比较重要的部件就是搅拌罐,其工作环境比较恶劣,再加上用户不注意日常保养,就造成了一些不必要的故障和经济损失,

自动上料搅拌机其中一个比较重要的部件就是搅拌罐,其工作环境比较恶劣,再加上用户不注意日常保养,就造成了一些不必要的故障和经济损失,自动上料搅拌罐日常维护保养如下:
One of the most important parts of the automatic feeding mixer is the mixing tank. Its working environment is relatively bad, and the user does not pay attention to the daily maintenance, which causes some unnecessary failures and economic losses. The daily maintenance of the automatic feeding mixing tank is as follows:
1.首先应该保养自动上料搅拌罐罐体,每次运完混凝土后及进清洗罐,要知道混凝土是更容易和钢铁粘结在一起的。
1. First of all, the tank body of the automatic feeding mixing tank should be maintained. After transporting the concrete and entering the cleaning tank every time, we should know that the concrete is easier to bond with the steel.
2.出料的均匀性问题是自动上料搅拌罐的一个重要指标之一,它直接影响着施工质量。在运送混凝土时,搅拌筒转速应节制在2~5r/min,在运送间隔较长可能混凝土的塌落度较大时,出料前应先将搅拌筒快速动弹5~10圈,使内里的混凝土能充实搅拌,这样出料的匀称性就会大大提高。若途中混凝失水,到工地应加水调解,并充实搅拌,虽然这种环境应只管制止,但是这样会使混凝土的质量得不到担保。有的用户在利用时不留意节制在运输历程中的转速,过快会增大燃油的耗损,过小则会造成混凝土离析。因此应严格根据要求来节制搅拌筒的转速,以提高混凝土运送质量。
2. The uniformity of discharge is one of the important indexes of automatic feeding mixing tank, which directly affects the construction quality. When transporting concrete, the rotation speed of mixing drum should be controlled at 2 ~ 5R / min. when the transportation interval is long and the slump of concrete is large, the mixing drum should be moved quickly for 5 ~ 10 circles before discharging, so that the concrete inside can be fully mixed, and the uniformity of discharging will be greatly improved. If water loss occurs in the process of coagulation, water should be added to the site for mediation and full mixing. Although this kind of environment should only be stopped, the quality of concrete will not be guaranteed. Some users do not pay attention to control the speed during transportation, too fast will increase fuel consumption, too small will cause concrete segregation. Therefore, the rotation speed of the mixing drum should be strictly controlled according to the requirements to improve the quality of concrete transportation.
3.混凝土限量不能高出罐体的方量,因为混凝土强度品级差别它的密度也差别,高强度混凝土一般密度也大,同样的体积,装多了对车会有一定损坏。输送混凝土的容量、质量及坍落度应切合车辆利用说明书中的规定,实时加注润滑油。
3. The limit of concrete should not be higher than the volume of the tank, because the density of concrete is also different due to the different strength grades. High strength concrete generally has a large density, and the same volume will cause certain damage to the car if it is loaded too much. The capacity, quality and slump of the transported concrete shall meet the requirements of the vehicle operation manual, and the lubricating oil shall be added in real time.
4.露天停放过的自动上料搅拌罐,装料前应先将搅拌筒以出料偏向旋转,把水泥罐内的积水放掉,确保运送混凝土的质量。
4. For the automatic feeding mixing tank that has been parked in the open air, before loading, the mixing drum should be rotated with the discharging direction to discharge the water in the cement tank, so as to ensure the quality of concrete transportation.

截屏,微信识别二维码

微信号:

点击微信号复制,添加好友

 打开微信